文万斌1 刘少华1 毕玉华1 彭宏伟1 代国雄 付全

（1-昆明理工大学云南省内燃机重点实验室云南昆明6505002-昆明云内动力股份有限公司）

Abstract：In order to study the effect of EGR and VNT on diesel engine performance,combustion and emission characteristics for plateau environment,one dimensional flow simulation model of diesel engine including EGR and VNT system was established based on bench testing using GT-POWER and numerical calculation and analysis were carried out.Results show that effective specific fuel consumption of diesel engine basically increases with the increase of EGR rate.When VNT open degree is relatively small, effective specific fuel consumption goes up slowly as EGR rate increases.Maximum cylinder pressure and temperature decrease with the increase of EGR rate.When EGR rate is constant,maximum cylinder pressure falls as VNT open degree goes up.Emission of NOxgradually decreases with the increase of EGR rate.And emission of NOxdecreases with the increase of VNT open degree when EGR rate remains constant.Particulate emissions of different operating conditions show different trends with the increase of EGR rate;Particulate emissions increase with a further increase of the EGR rate.Also,when EGR rate stays the same,particulate emissions basically fall with decrease of VNT open degree.

Keywords：Plateau environment,Exhaust gas recirculation,Variable nozzle turbocharger,Diesel engine, Simulation

高原环境下EGR与VNT对柴油机性能影响的仿真研究*

文万斌1刘少华1毕玉华1彭宏伟1代国雄2付全2

（1-昆明理工大学云南省内燃机重点实验室云南昆明6505002-昆明云内动力股份有限公司）

为了研究在高原环境下排气再循环（EGR）与可变喷嘴涡轮增压（VNT）对柴油机性能，燃烧和排放的影响，在台架测试的基础上，应用GT-POWER软件，建立了带EGR与VNT系统的柴油机一维流动仿真模型，并进行了模拟计算与分析。研究表明，随着EGR率增加，柴油机有效燃油消耗率基本呈现增加的趋势。当VNT开度比较小时，有效燃油消耗率随EGR率增加的幅度也较低。最大缸内压力和最高缸内温度随着EGR率增加而降低。在EGR率相同时，最大缸压随着VNT开度增大而减小。NOx排放随着EGR率的增大而逐渐降低，EGR率一定时，NOx排放随VNT开度的增大而逐渐降低。在不同工况下，随着EGR率增加，颗粒物排放呈现不同的变化趋势；当EGR率进一步增大时，颗粒物排放呈现增加的趋势。在相同EGR率时，颗粒物排放基本随VNT开度的减小逐渐降低。

高原环境EGRVNT柴油机性能仿真

Abstract：In order to study the effect of EGR and VNT on diesel engine performance,combustion and emission characteristics for plateau environment,one dimensional flow simulation model of diesel engine including EGR and VNT system was established based on bench testing using GT-POWER and numerical calculation and analysis were carried out.Results show that effective specific fuel consumption of diesel engine basically increases with the increase of EGR rate.When VNT open degree is relatively small, effective specific fuel consumption goes up slowly as EGR rate increases.Maximum cylinder pressure and temperature decrease with the increase of EGR rate.When EGR rate is constant,maximum cylinder pressure falls as VNT open degree goes up.Emission of NOxgradually decreases with the increase of EGR rate.And emission of NOxdecreases with the increase of VNT open degree when EGR rate remains constant.Particulate emissions of different operating conditions show different trends with the increase of EGR rate;Particulate emissions increase with a further increase of the EGR rate.Also,when EGR rate stays the same,particulate emissions basically fall with decrease of VNT open degree.

Keywords：Plateau environment,Exhaust gas recirculation,Variable nozzle turbocharger,Diesel engine, Simulation

引言

采用排气再循环（EGR）技术能够有效降低柴油机氮氧化物（NOx）排放[1-3]。但是在高原环境下，大气压力随着海拔升高而下降，涡轮进排气压力差增大，导致涡轮超速，致使压比升高，加剧传统增压中冷柴油机在某些工况下的进排气逆差问题（进气压力大于排气压力），导致EGR率波动大以及EGR响应迟缓，从而影响柴油机的燃烧和排放。……