烟气调质PID调节研究与应用
2016-10-21廖明洁



摘 要: 为了提高电除尘的除尘效率,托克托发电公司增加烟气调质系统产生SO3调质剂以气体形式喷射入烟气,与飞灰充分结合,在灰尘表面形成一层薄薄的导电膜,以减小灰粒的比电阻,使灰尘的比电阻达到理想的范围,易于被电除尘器捕获,而最佳的三氧化硫喷射率由锅炉负荷、浊度和烟气温度输入信号决定。其中,烟气温度调节尤为重要,整个烟气调质正常投入喷射80%条件都与温度有关,也是热工自动保护的重点,托电公司烟气调质采用AB公司的PLC控制系统,利用工业PID调节方式来完成对加热器可控硅的控制,保证空气温度的最佳,增加系统的除尘效率和可靠性。
关键词:烟气调质 空气加热器 PID调节 可靠性
Abstract:In order to improve the collection efficiency of the ESP, the Tuoketuo power companies to increase gas conditioning system to produce SO3 quenching agent is injected into the flue gas in the form of fully integrated with the fly ash, dust the surface of a thin layer of conductive film, ash particles to reduce the specific resistance, so that the specific resistance of dust to achieve the desired range, is easy to be caught electrostatic precipitator, and the optimum injection rate of sulfur trioxide boiler load, turbidity, and the input signal determines the flue gas temperature. Among them, the flue gas temperature control is particularly important, the entire gas conditioning spray 80 percent of normal input conditions are related to temperature, but also the thermal protection of automatic focus, supporting Power Company Gas Conditioning uses AB Corporation PLC control system, using industry PID regulation mode to complete the heater SCR control to ensure optimum air temperature, increasing collection efficiency and reliability of the system.
Key words:Flue gas conditioning, Air Heater, PID regulation, reliability
中图分类号:X701 文献标识码:A 文章编号:1003-9082(2016)06-0286-02
一、煙气调质系统投入背景
从2003年6月机组投产以来,托电为华北电网、京津唐地区、特别是北京地区的供电做出了巨大的贡献。托电已经成为华北电网一个极为重要的电源点。同时托电的建设也是落实国家的“西电东送”战略的重要组成部分。
托电发电用的准格尔煤发热量偏低,燃烧后灰样中SiO2和AI2O3含量高,比电阻高,目前对于国内生产的电除尘器来说,较难以捕获,电除尘器效率达不到设计要求,所以粉尘排放严重超标,造成环境污染,同时间接的造成引风机叶片严重磨损,威胁机组的安全稳定运行。
二、烟气调质系统介绍
煤在燃烧过程中,其中的硫和空气中的氧化合生成二氧化硫,其中约0.4%-3.0%的二氧化硫在炉膛中被进一步氧化成三氧化硫,三氧化硫和烟气中的水分结合形成硫酸,以极薄的一层均匀地凝结于飞灰颗粒的表面。……
